Final Word: Think Safety and Use Common Sense to Meet New IND GMP Regulations - FDA has eased GMP regulations to help small manufacturers with limited personnel and facilities - BioPharm International

ADVERTISEMENT

Final Word: Think Safety and Use Common Sense to Meet New IND GMP Regulations
FDA has eased GMP regulations to help small manufacturers with limited personnel and facilities


BioPharm International
Volume 19, Issue 4


James A. Taylor, PhD
On January 17, 2006, the FDA released new regulations, effective June 1, 2006, which affect the production of most investigational drug and biologic products intended for phase 1 clinical trials. These regulations are much broader in scope than the Exploratory IND guidance released on the same day, and which apply only to low-risk, CDER-regulated clinical studies.

The new regulations, which acknowledge that manufacturing controls should be appropriate to each stage of development, apply specifically to the section of the Code of Federal Regulations (Title 21 CFR Part 211) that refers to drug product manufacturing; they extend, by implication, to the production of active pharmaceutical ingredient (API), i.e., bulk drug substance. The new regulations apply to phase 1 clinical trials for all drug and biological products not previously tested in a later phase of clinical testing, but do not apply to certain cell-based products.




In essence, the FDA has eased formal GMP regulations for phase 1 studies to assist small academic and commercial manufacturers, who have limited personnel and facilities, produce initial batches of drug product. In practice, the regulations apply more broadly to larger contract manufacturers and sponsors in the production of API and drug product as well.

In determining where to apply the new regulations most rigidly, FDA will consider patient safety and degree of risk as key factors, and will apply the regulations when greater risk is present. For example, the farther away the production step is from final product, the less risk will apply (assuming no substantive safety risks are introduced at the initial stage that cannot be removed by appropriate downstream purification). In the preparation of a sterile parenteral product, on the other hand, FDA reviewers will show greater concern with the final aseptic processing step than in the number of steps to produce API, the choice of a starting material, or the level of early GMP compliance.

In lieu of full GMP compliance, FDA will require manufacturers to maintain proper safety controls in the form of tentative release criteria. The FDA will also require manufacturers to maintain a series of written procedures for all manufacturing processes and controls; to ensure that facilities and equipment are used properly; and to maintain an accurate production record of all phase 1 clinical supplies. FDA has issued a guidance to describe this. When limited resources exist, contract vendors are generally best suited to support phase 1 manufacturing.

Manufacturers should not presume that FDA will permit manufacturing of phase 1 clinical supplies outside the guiding principles of GMP regulations. Manufacturers should assume that FDA will question or audit manufacturing operations when safety concerns arise. Consultation with FDA will still be beneficial in certain situations and perhaps can be best handled through a pre-IND meeting.

The new GMP regulations for drugs in phase1 clinical trials are based on common sense, adherence to good scientific practices, and continuing concern for patient safety. In this setting, contract manufacturers and sponsors should do the following:

  • Establish written policies and procedures if they do not already exist
  • Adopt a more rigid approach towards the final steps of drug product production
  • Obtain a second opinion from an experienced consultant or FDA reviewer directly, as part of a pre-IND meeting. When in doubt, err on the side of safety.

James A. Taylor, PhD, Partner, Merchant-Taylor International, 162 S. Rancho Santa Fe Rd., Encinitas, CA 92024, (tel) 858.675.0808. (fax) 858 675.1047,

blog comments powered by Disqus

ADVERTISEMENT

ADVERTISEMENT

First Biosimilar Application Kicks Off Legal Battle
October 31, 2014
FDA Approves Pfizer's Trumenba for the Prevention of Meningitis B
October 30, 2014
EMA: Extrapolation Across Indications for Biosimilars a Possibility
October 30, 2014
Bristol-Myers Squibb Announces Agreement to Acquire HER2-Targeted Cancer Treatment
October 29, 2014
Amgen, Sanofi, and Ono Pharmaceuticals Partner with Universities on Transmembrane Protein Research
October 28, 2014
Author Guidelines
Source: BioPharm International,
Click here